en
IMPORTANT

The Owner's Manual for this vehicle contains warnings, instructions and other information you must read and fully understand before safely riding or performing maintenance on this vehicle. Always follow the warnings and instructions in Owner's Manual.

Click the link above for the Table Of Contents, or download a full PDF of the Owner Manual in the Owner Support area of Polaris.com.

Maintenance Intervals

NOTICE

The maintenance interval charts outline required maintenance and inspection based on estimated vehicle engine hours / miles. Each table states the number of hours / miles that service is required on the vehicle. Some items or components may need to be serviced more often due to severe use, such as operation in water or under severe loads. When the vehicle goes beyond 400 hours, return to the 25 hours chart and start the interval process over.

5 Hour / Break-in Service

Item Remarks
 
▶ Engine Oil Change (Break-in) Perform a break-in oil change at one month
  Drive Chain (Break-in) Adjust and lubricate
▶
■		 Brake pad wear (Break-in) Inspect periodically

10 Hour / 100 mile (160 km) Service

Item Remarks
 
■ Valve Clearance (Break-in) Valve lash adjustment: Every 50 hours after first 10-hour adjustment

25 Hour / 250 mile (400 km) Service

Item Remarks
 
  Fuel System Inspect; cycle key to pressurize fuel pump; check lines and fittings for leaks and abrasion
  Battery Check terminals; clean; test
▶ Engine Oil Change  

50 Hour / 500 mile (800 km) Service

Item Remarks
 
▶ Fuel System Inspect; cycle key to pressurize fuel pump; check lines and fittings for leaks and abrasion
  Battery Check terminals; clean; test
▶ Engine Oil Change  
■ Valve Clearance Valve lash adjustment
▶ General Lubrication Lubricate all fittings, pivots, cables, etc.
  Shift Linkage Inspect, lubricate, adjust
■ Steering Lubricate
▶ Front Suspension Lubricate
▶ Rear Suspension Lubricate
  Throttle Body Intake Duct Inspect duct for proper sealing/air leaks

▶ Perform these procedures more often for vehicles subjected to severe use.

■ Have an authorized POLARIS dealer or other qualified person perform these services.

75 Hour / 750 mile (1200 km) Service

Item Remarks
 
  Fuel System Inspect; cycle key to pressurize fuel pump; check lines and fittings for leaks and abrasion
  Battery Check terminals; clean; test
▶ Engine Oil Change  

100 Hour / 1000 mile (1600 km) Service

Item Remarks
 
  Battery Check terminals; clean; test
▶ Transmission Oil Change transmission fluid; or change before storage
▶ Engine Oil Change  
■ Valve Clearance Valve lash adjustment
▶ General Lubrication Lubricate all fittings, pivots, cables, etc.
  Shift Linkage Inspect, lubricate, adjust
■ Steering Lubricate
▶ Front Suspension Lubricate
▶ Rear Suspension Lubricate
  Throttle Body Intake Duct Inspect duct for proper sealing/air leaks
■ Fuel System / Filter Cycle key to pressurize fuel pump; check for leaks at fill cap, fuel lines/rail and fuel pump
▶ Spark Plug Inspect; replace as needed
▶ Engine Mounts Inspect
  Exhaust Muffler / Pipe Inspect
▶ Wiring Inspect for wear, routing, security; apply dielectric grease to connectors subjected to water, mud, etc.
■ Clutches (Drive and Driven) Inspect; clean; replace worn parts
  Drive belt Inspect; replace as needed
■ Front wheel bearings Inspect; replace as needed

125 Hour / 1250 mile (2000 km) Service

Item Remarks
 
  Fuel System Inspect; cycle key to pressurize fuel pump; check lines and fittings for leaks and abrasion
  Battery Check terminals; clean; test
▶ Engine Oil Change  

▶ Perform these procedures more often for vehicles subjected to severe use.

■ Have an authorized POLARIS dealer or other qualified person perform these services.

150 Hour / 1500 mile (2400 km) Service

Item Remarks
 
▶ Fuel System Inspect; cycle key to pressurize fuel pump; check lines and fittings for leaks and abrasion
  Battery Check terminals; clean; test
▶ Engine Oil Change  
■ Valve Clearance Valve lash adjustment
▶ General Lubrication Lubricate all fittings, pivots, cables, etc.
  Shift Linkage Inspect, lubricate, adjust
■ Steering Lubricate
▶ Front Suspension Lubricate
▶ Rear Suspension Lubricate
  Throttle Body Intake Duct Inspect duct for proper sealing/air leaks

175 Hour / 1750 mile (2800 km) Service

Item Remarks
 
  Fuel System Inspect; cycle key to pressurize fuel pump; check lines and fittings for leaks and abrasion
  Battery Check terminals; clean; test
▶ Engine Oil Change  

200 Hour / 2000 mile (3200 km) Service

Item Remarks
 
  Battery Check terminals; clean; test
▶ Transmission Oil Change transmission fluid; or change before storage
▶ Engine Oil Change  
■ Valve Clearance Valve lash adjustment
▶ General Lubrication Lubricate all fittings, pivots, cables, etc.
  Shift Linkage Inspect, lubricate, adjust
■ Steering Lubricate
▶ Front Suspension Lubricate
▶ Rear Suspension Lubricate
  Throttle Body Intake Duct Inspect duct for proper sealing/air leaks
■ Fuel System / Filter Cycle key to pressurize fuel pump; check for leaks at fill cap, fuel lines/rail and fuel pump
▶ Spark Plug Inspect; replace as needed
▶ Engine Mounts Inspect
  Exhaust Muffler / Pipe Inspect
▶ Wiring Inspect for wear, routing, security; apply dielectric grease to connectors subjected to water, mud, etc.
■ Clutches (Drive and Driven) Inspect; clean; replace worn parts
  Drive belt Inspect; replace as needed
■ Front wheel bearings Inspect; replace as needed
■ Brake fluid Change every two years

▶ Perform these procedures more often for vehicles subjected to severe use.

■ Have an authorized POLARIS dealer or other qualified person perform these services.

225 Hour / 2250 mile (3600 km) Service

Item Remarks
 
  Fuel System Inspect; cycle key to pressurize fuel pump; check lines and fittings for leaks and abrasion
  Battery Check terminals; clean; test
▶ Engine Oil Change  

250 Hour / 2500 mile (4000 km) Service

Item Remarks
 
▶ Fuel System Inspect; cycle key to pressurize fuel pump; check lines and fittings for leaks and abrasion
  Battery Check terminals; clean; test
▶ Engine Oil Change  
■ Valve Clearance Valve lash adjustment
▶ General Lubrication Lubricate all fittings, pivots, cables, etc.
  Shift Linkage Inspect, lubricate, adjust
■ Steering Lubricate
▶ Front Suspension Lubricate
▶ Rear Suspension Lubricate
  Throttle Body Intake Duct Inspect duct for proper sealing/air leaks

275 Hour / 2750 mile (4400 km) Service

Item Remarks
 
  Fuel System Inspect; cycle key to pressurize fuel pump; check lines and fittings for leaks and abrasion
  Battery Check terminals; clean; test
▶ Engine Oil Change  

▶ Perform these procedures more often for vehicles subjected to severe use.

■ Have an authorized POLARIS dealer or other qualified person perform these services.

300 Hour / 3000 mile (4800 km) Service

Item Remarks
 
  Battery Check terminals; clean; test
▶ Transmission Oil Change transmission fluid; or change before storage
▶ Engine Oil Change  
■ Valve Clearance Valve lash adjustment
▶ General Lubrication Lubricate all fittings, pivots, cables, etc.
  Shift Linkage Inspect, lubricate, adjust
■ Steering Lubricate
▶ Front Suspension Lubricate
▶ Rear Suspension Lubricate
  Throttle Body Intake Duct Inspect duct for proper sealing/air leaks
■ Fuel System / Filter Cycle key to pressurize fuel pump; check for leaks at fill cap, fuel lines/rail and fuel pump
▶ Spark Plug Inspect; replace as needed
▶ Engine Mounts Inspect
  Exhaust Muffler / Pipe Inspect
▶ Wiring Inspect for wear, routing, security; apply dielectric grease to connectors subjected to water, mud, etc.
■ Clutches (Drive and Driven) Inspect; clean; replace worn parts
  Drive belt Inspect; replace as needed
■ Front wheel bearings Inspect; replace as needed
  Spark Arrester Clean out

325 Hour / 3250 mile (5200 km) Service

Item Remarks
 
  Fuel System Inspect; cycle key to pressurize fuel pump; check lines and fittings for leaks and abrasion
  Battery Check terminals; clean; test
▶ Engine Oil Change  

350 Hour / 3500 mile (5600 km) Service

Item Remarks
 
▶ Fuel System Inspect; cycle key to pressurize fuel pump; check lines and fittings for leaks and abrasion
  Battery Check terminals; clean; test
▶ Engine Oil Change  
■ Valve Clearance Valve lash adjustment
▶ General Lubrication Lubricate all fittings, pivots, cables, etc.
  Shift Linkage Inspect, lubricate, adjust
■ Steering Lubricate
▶ Front Suspension Lubricate
▶ Rear Suspension Lubricate
  Throttle Body Intake Duct Inspect duct for proper sealing/air leaks

▶ Perform these procedures more often for vehicles subjected to severe use.

■ Have an authorized POLARIS dealer or other qualified person perform these services.

375 Hour / 3750 mile (6000 km) Service

Item Remarks
 
  Fuel System Inspect; cycle key to pressurize fuel pump; check lines and fittings for leaks and abrasion
  Battery Check terminals; clean; test
▶ Engine Oil Change  

400 Hour / 4000 mile (6400 km) Service

Item Remarks
 
  Battery Check terminals; clean; test
▶ Transmission Oil Change transmission fluid; or change before storage
▶ Engine Oil Change  
■ Valve Clearance Valve lash adjustment
▶ General Lubrication Lubricate all fittings, pivots, cables, etc.
  Shift Linkage Inspect, lubricate, adjust
■ Steering Lubricate
▶ Front Suspension Lubricate
▶ Rear Suspension Lubricate
  Throttle Body Intake Duct Inspect duct for proper sealing/air leaks
■ Fuel System / Filter Cycle key to pressurize fuel pump; check for leaks at fill cap, fuel lines/rail and fuel pump
▶ Spark Plug Inspect; replace as needed
▶ Engine Mounts Inspect
  Exhaust Muffler / Pipe Inspect
▶ Wiring Inspect for wear, routing, security; apply dielectric grease to connectors subjected to water, mud, etc.
■ Clutches (Drive and Driven) Inspect; clean; replace worn parts
  Drive belt Inspect; replace as needed
■ Front wheel bearings Inspect; replace as needed
■ Brake fluid Change every two years

▶ Perform these procedures more often for vehicles subjected to severe use.

■ Have an authorized POLARIS dealer or other qualified person perform these services.