IMPORTANT

The Owner's Manual for this vehicle contains warnings, instructions and other information you must read and fully understand before safely riding or performing maintenance on this vehicle. Always follow the warnings and instructions in Owner's Manual.

Click the link above for the Table Of Contents, or download a full PDF of the Owner Manual in the Owner Support area of Polaris.com.

2023 Indian Scout / Indian Scout Sixty Owner’s Manual

P/N 9940886

Copyright Info

All information contained within this publication is based on the latest product information available at the time of publication. Product improvements or other changes may result in differences between this manual and the motorcycle. Depictions and/or procedures in this publication are intended for reference use only.

No liability can be accepted for omissions or inaccuracies. Indian Motorcycle Company reserves the right to make changes at any time, without notice and without incurring obligation to make the same or similar changes to motorcycles previously built. Any reprinting or reuse of the depictions and/or procedures contained within, whether whole or in part, is expressly prohibited.

Trademarks

Unless noted, trademarks are the property of Indian Motorcycle International, LLC

Ride Command® is a registered trademark of Polaris Industries, Inc. Pirelli® is a registered trademark of PIRELLI & C.S.P.A. Motorcycle Safety Foundation^SM is a service mark of Motorcycle Safety Foundation Corporation. NGK® is a registered trademark of NGK Spark Plug Co., Ltd. BatteryMINDer® is a registered trademark of VDC Electronics, Inc. iOS® is a registered trademark of CISCO SYSTEMS, INC. Google Play® is a registered trademark of GOOGLE LLC. Bluetooth® is a registered trademark of Bluetooth Sig, Inc. Osram® is a registered trademark of OSRAM GMBH GESELLSCHAFT MIT BESCHRÄNKTER HAFTUNG. Axalta® is a registered trademark of Axalta Coating Systems IP Co. LLC.

i 2023 Indian Scout / Indian Scout Sixty Owner’s Manual
ii Congratulations!
iii Safety Symbols and Signal Words
Table Of Contents
Chapter 1: Introduction
- 1.1.1: Service and Warranty Information
  - 1.1.1.1: Operating Motorcycle Outside the U.S.A.
- 1.1.2: Identification Number Record
- 1.1.3: Engine Identification Number
- 1.1.4: Key Identification Number
Chapter 2: Safety
- 2.2.1: About the Rider’s Manual
- 2.2.2: Safe Riding Practices
  - 2.2.2.1: Motorcycling Has Inherent Risks
  - 2.2.2.2: Design Characteristics Affect How You Should Ride The Motorcycle
  - 2.2.2.3: Follow These General Safe Riding Practices
- 2.2.3: Carrying a Passenger
- 2.2.4: Anti-Lock Brake System
  Response (if equipped)
- 2.2.5: Protective Apparel
- 2.2.6: Use of Accessories
- 2.2.7: Modifications
- 2.2.8: Parking the Motorcycle
- 2.2.9: Saddlebags
- 2.2.10: Carrying Cargo
- 2.2.11: Transporting the Motorcycle
- 2.2.12: Fuel and Exhaust Safety
- 2.2.13: Safety Maintenance
- 2.2.14: Electromagnetic Interference
- 2.2.15: Gross Vehicle Weight Rating (GVWR)
- 2.2.16: Reporting Safety Defects
- 2.2.17: Reporting Safety Defects (Canada)
- 2.2.18: Safety and Information Labels
Chapter 3: Features and Controls
- 3.3.1: Indian Scout
- 3.3.2: Indian Scout Sixty
- 3.3.3: Console
- 3.3.4: Switch Locations
  - 3.3.4.1: Left Control
  - 3.3.4.2: Right Control
- 3.3.5: Switch Symbols
- 3.3.6: Switch Functions
  - 3.3.6.1: High/Low Headlight Beam Switch
  - 3.3.6.2: Hazard Switch
  - 3.3.6.3: Horn Switch
  - 3.3.6.4: Mode Switch
  - 3.3.6.5: Engine Stop/Run Switch
  - 3.3.6.6: Engine Starter Switch
  - 3.3.6.7: Ignition/Light Key Switch
- 3.3.7: Instrument Cluster
  - 3.3.7.1: Speedometer
  - 3.3.7.2: Indicator Lamps
  - 3.3.7.3: MFD Tell-Tales
- 3.3.8: Multi-Function Display Modes
  - 3.3.8.1: Odometer
  - 3.3.8.2: Trip Odometer
  - 3.3.8.3: Engine Speed
  - 3.3.8.4: Gear Indicator
  - 3.3.8.5: Battery Voltage
  - 3.3.8.6: Display Units (Standard/Metric)
  - 3.3.8.7: Clock
  - 3.3.8.8: Engine Error Codes
  - 3.3.8.9: Diagnostic Functionality
  - 3.3.8.10: Over Temperature Display and Warning Indicator
- 3.3.9: Battery Charge Port/Heated Gear Plug
- 3.3.10: Throttle Control Grip
- 3.3.11: Clutch Lever
- 3.3.12: Mirrors
- 3.3.13: Feeler Pegs
- 3.3.14: Gear Shift Lever
- 3.3.15: Sidestand
- 3.3.16: Steering Lock (if equipped)
- 3.3.17: Brakes
  - 3.3.17.1: Anti-Lock Brake System (ABS) (if equipped)
  - 3.3.17.2: Front Brake Lever
  - 3.3.17.3: Rear Brake Pedal
Chapter 4: Pre-Ride Inspections
- 4.4.1: Overview
  - 4.4.1.1: Electrical Inspections
  - 4.4.1.2: General Inspections
- 4.4.2: Engine Oil Level
- 4.4.3: Tires
  - 4.4.3.1: Tire Pressure
  - 4.4.3.2: Tire Condition
  - 4.4.3.3: Tire Tread Depth
- 4.4.4: Front Brake Fluid Level
- 4.4.5: Front Brake Lever
- 4.4.6: Rear Brake Pedal
- 4.4.7: Rear Brake Fluid Level
- 4.4.8: Brake Lines
- 4.4.9: Mechanical Clutch
- 4.4.10: Throttle
- 4.4.11: Front Suspension
- 4.4.12: Rear Suspension
- 4.4.13: Rear Drive Belt
- 4.4.14: Fuel Level
- 4.4.15: Sidestand
- 4.4.16: Fasteners
Chapter 5: Operation
- 5.5.1: Overview
- 5.5.2: Break-In Maintenance
- 5.5.3: Engine Break-In
  - 5.5.3.1: Operating Speeds and Gears
- 5.5.4: Fueling
- 5.5.5: Priming the Fuel System
- 5.5.6: Starting the Engine
  - 5.5.6.1: Idle Timer Shutdown Notification
- 5.5.7: Misfire Detection
- 5.5.8: Shifting Gears
  - 5.5.8.1: Shifting Gears While Stationary
  - 5.5.8.2: Shifting Gears While Driving
  - 5.5.8.3: Recommended Shift Points
- 5.5.9: Braking
- 5.5.10: Accelerating
- 5.5.11: Stopping the Engine
- 5.5.12: Parking
- 5.5.13: Parking on a Slope
- 5.5.14: Parking on a Soft Surface
Chapter 6: Maintenance
- 6.6.1: Service Procedures
- 6.6.2: Safety During Service Procedures
- 6.6.3: Road Tests
- 6.6.4: Major Maintenance
- 6.6.5: Periodic Maintenance
  - 6.6.5.1: Severe Use Definition
  - 6.6.5.2: Maintenance Table Key
  - 6.6.5.3: Periodic Maintenance Table
- 6.6.6: Engine Oil/Filter Change
- 6.6.7: Cooling System
  - 6.6.7.1: Coolant Level Inspection
- 6.6.8: Air Filter
- 6.6.9: Fuel Filter
- 6.6.10: Fuel System Depressurization
- 6.6.11: Fuel Tank Removal
- 6.6.12: Fuel Tank Installation
- 6.6.13: Drive Belt Maintenance
  - 6.6.13.1: Lifting the Motorcycle
  - 6.6.13.2: Drive Belt Tension Check
  - 6.6.13.3: Drive Belt Tension Adjustment
  - 6.6.13.4: Drive Belt Alignment
  - 6.6.13.5: Rear Drive Belt Cleaning
  - 6.6.13.6: Rear Drive Belt Wear Analysis
  - 6.6.13.7: Rear Drive Belt Condition
- 6.6.14: Rear Shock Preload (Ride Height) Inspection
- 6.6.15: Rear Shock Preload (Ride Height) Adjustment
- 6.6.16: Swing Arm/Rear Axle Inspection
- 6.6.17: Front Fork/Suspension Inspection
- 6.6.18: Steering Head Inspection
- 6.6.19: Crankcase Breather Hoses
- 6.6.20: Evaporative Emission Control System (California and International Models)
- 6.6.21: Fuel System Components
- 6.6.22: Throttle Control Inspection
- 6.6.23: Sidestand Lubrication
- 6.6.24: Mechanical Clutch
  - 6.6.24.1: Mechanical Clutch Lever Freeplay
  - 6.6.24.2: Mechanical Clutch Lever Lubrication
  - 6.6.24.3: Mechanical Clutch Cable Lubrication
- 6.6.25: Brakes
  - 6.6.25.1: Rear Brake Pedal
  - 6.6.25.2: Brake Hoses/Connections
  - 6.6.25.3: Brake Fluid Precautions
  - 6.6.25.4: Rear Brake Fluid
  - 6.6.25.5: Front Brake Lever
  - 6.6.25.6: Front Brake Fluid
  - 6.6.25.7: Brake Pads
  - 6.6.25.8: Brake Disc Inspection / Cleaning
  - 6.6.25.9: Anti-Lock Brake System (ABS) Tone Ring/Sensor Inspection (if equipped)
- 6.6.26: Wheel Inspection
- 6.6.27: Wheel Alignment
- 6.6.28: Front Wheel Installation
- 6.6.29: Tires
  - 6.6.29.1: Tire Replacement
  - 6.6.29.2: Tire Condition
  - 6.6.29.3: Tire Pressure
  - 6.6.29.4: Tire Pressure Chart
  - 6.6.29.5: Tire Tread Depth
- 6.6.30: Spark Plugs
- 6.6.31: Seat Removal
  - 6.6.31.1: Indian Scout
  - 6.6.31.2: Indian Scout Sixty
- 6.6.32: Headlight
  - 6.6.32.1: Headlight Aim Inspection
  - 6.6.32.2: Headlight Aim Adjustment
  - 6.6.32.3: Headlight Lamp Replacement
- 6.6.33: Battery
  - 6.6.33.1: Battery Removal
  - 6.6.33.2: Battery Installation
  - 6.6.33.3: Battery Charging
- 6.6.34: Battery Charging and Maintenance
  - 6.6.34.1: AGM Battery Charger Recommendations
  - 6.6.34.2: AGM Battery Charging Recommendations – Low Charge
  - 6.6.34.3: AGM Battery Charging Recommendations – Deeply Discharged (Below 3 Volts)
  - 6.6.34.4: AGM Battery Charging Recommendations Table
  - 6.6.34.5: AGM Battery Maintenance Tips
- 6.6.35: Fuse Replacement
- 6.6.36: Electrical Precautions
- 6.6.37: Exhaust System Inspection
- 6.6.38: Re-torque Exhaust Hose Clamps
- 6.6.39: Exhaust System Components
- 6.6.40: Elevating the Motorcycle
- 6.6.41: Road Test
- 6.6.42: Fastener Inspection
- 6.6.43: Fastener Torques
- 6.6.44: Troubleshooting
  - 6.6.44.1: Engine Cranks But Will Not Start
  - 6.6.44.2: Starter Motor Clicks, Does Not Turn or Turns Slowly
  - 6.6.44.3: Engine Starts But Misses or Runs Poorly
  - 6.6.44.4: Shifting Difficulties or Hard to Find Neutral
  - 6.6.44.5: Engine Overheating
  - 6.6.44.6: Battery Charging Rate Low or Battery Discharges
  - 6.6.44.7: Brake Noise/Poor Brake Performance
  - 6.6.44.8: Anti-Lock Brake Light Remains Illuminated or Illuminates Intermittently
Chapter 7: Cleaning and Storage
- 7.7.1: Cleaning Products
- 7.7.2: Washing the Motorcycle
- 7.7.3: Windshield Care (if equipped)
- 7.7.4: Matte Clear Coat Finish Care
- 7.7.5: Gloss Clear Coat Finish Care
- 7.7.6: Leather Care
  - 7.7.6.1: Leather Facts
    - 7.7.6.1.1: Exposure to Sun
    - 7.7.6.1.2: Exposure to Moisture
    - 7.7.6.1.3: Exposure to Dirt/Dust
  - 7.7.6.2: Leather Care Dressing
    - 7.7.6.2.1: Application
  - 7.7.6.3: Leather Care Frequently Asked Questions
- 7.7.7: Storage Area Preparation
- 7.7.8: Fuel Stabilizer
- 7.7.9: Tire Inflation
- 7.7.10: Engine Protection
- 7.7.11: Cooling System
- 7.7.12: Battery Care
- 7.7.13: Maintenance During Storage
- 7.7.14: Rodents
- 7.7.15: Park and Cover the Motorcycle
- 7.7.16: Removal From Storage
Chapter 8: Specifications
- 8.8.1: Indian Scout
- 8.8.2: Indian Scout Sixty
- 8.8.3: Fuel Recommendation
- 8.8.4: Engine Oil Recommendation
- 8.8.5: Fork Oil
- 8.8.6: Brake Fluid
Chapter 9: Warranty
- 9.9.1: INDIAN MOTORCYCLE Warranty Policy
  - 9.9.1.1: LIMITED WARRANTY
  - 9.9.1.2: REGISTRATION
  - 9.9.1.3: WARRANTY COVERAGE AND EXCLUSIONS:
    LIMITATIONS OF WARRANTIES AND REMEDIES
    - 9.9.1.3.1: LUBRICANTS AND FLUIDS
  - 9.9.1.4: HOW TO OBTAIN WARRANTY SERVICE
  - 9.9.1.5: EXPORTED VEHICLES
  - 9.9.1.6: NOTICE
  - 9.9.1.7: Motorcycle Noise Regulation
  - 9.9.1.8: Noise Emission Warranty
- 9.9.2: Emissions Control System Warranty
  - 9.9.2.1: INDIAN MOTORCYCLE COMPANY - Emission Control System Warranty Statement
    - 9.9.2.1.1: Your Warranty Rights and Obligations
    - 9.9.2.1.2: Manufacturer’s Warranty Coverage
    - 9.9.2.1.3: Owner’s Warranty Responsibilities
    - 9.9.2.1.4: I. Coverage
    - 9.9.2.1.5: II. Limitations
    - 9.9.2.1.6: III. Limited Liability
    - 9.9.2.1.7: IV. Legal Rights
    - 9.9.2.1.8: V. This warranty is in addition to the INDIAN MOTORCYCLE Limited Motorcycle Warranty
    - 9.9.2.1.9: VI. Additional Information
Chapter 10: Maintenance Log
- 10.10.1: Maintenance Log
Index