en
IMPORTANT

The Owner's Manual for this vehicle contains warnings, instructions and other information you must read and fully understand before safely riding or performing maintenance on this vehicle. Always follow the warnings and instructions in Owner's Manual.

Click the link above for the Table Of Contents, or download a full PDF of the Owner Manual in the Owner Support area of Polaris.com.

Maintenance Intervals

NOTICE

Inspection may reveal the need for replacement parts. Always use genuine Slingshot parts.

IMPORTANT

The AutoDrive hydraulic system contains lifetime fluid and is non-servicable. Do not attempt to open the sealed system.

WARNING

Improperly performing the procedures marked for a to Dealer service could result in component failure and lead to serious injury or death. Have an authorized Slingshot dealer perform these services.

The maintenance interval charts outline required maintenance and inspection based on vehicle miles. Each table states the number of miles that service is required on the vehicle. Some items or components may need to be serviced more often due to severe use. When the vehicle goes beyond 150,000 miles, return to the 500 mile chart and start the interval process over.

500 mi (800 km) Service

Code Item Action
D / XU Air Filter Inspect; replace as necessary
D ABS components Inspect
  Battery Check terminals; clean; test
D Brake Fluid Change every two years (DOT 4)
XU Brake Pads Inspect pad wear; replace if worn beyond service limit
D Brake Pedal Inspect; adjust if necessary
  Clutch Fluid Inspect; add fluid as required
D Clutch Pedal Inspect; adjust if necessary
XU / E Coolant Hoses Inspect
D Crankcase Vent Inspect
D Drive Belt Inspect
D Driveshaft Yoke Inspect
XU / E Engine Oil & Filter Change Change oil and filter, inspect used oil for contaminants
D / E Evaporative Emission Control System Inspect
E Exhaust System Inspect; tighten, adjust
D Fasteners Inspect; tighten if necessary
D Fuel System Inspect; clean
D Headlamps Inspect; adjust if necessary
D Radio / Radio Software Update annually. Please see your dealer.
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
D Steering Inspect
D Swingarm Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

5,000 mi (8,000 km)Service

Code Item Action
D / XU Air Filter Inspect; replace as necessary
D ABS components Inspect
  Battery Check terminals; clean; test
D Brake Fluid Change every two years (DOT 4)
XU Brake Pads Inspect pad wear; replace if worn beyond service limit
D Brake Pedal Inspect; adjust if necessary
  Clutch Fluid Inspect; add fluid as required
D Clutch Pedal Inspect; adjust if necessary
XU / E Coolant Hoses Inspect
D Crankcase Vent Inspect
D Drive Belt Inspect
D Driveshaft Yoke Inspect
XU / E Engine Oil & Filter Change Change oil and filter, inspect used oil for contaminants
D / E Evaporative Emission Control System Inspect
E Exhaust System Inspect; tighten, adjust
D Fasteners Inspect; tighten if necessary
D Fuel System Inspect; clean
D Radio / Radio Software Update annually. Please see your dealer.
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
D Steering Inspect
D Swingarm Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

10,000 mi (16,000 km) Service

Code Item Action
D / XU Air Filter Inspect; replace as necessary
D / XU Angle Drive Fluid Replace fluid
D ABS components Inspect
  Battery Check terminals; clean; test
D Brake Fluid Change every two years (DOT 4)
XU Brake Pads Inspect pad wear; replace if worn beyond service limit
D Brake Pedal Inspect; adjust if necessary
  Clutch Fluid Inspect; add fluid as required
D Clutch Pedal Inspect; adjust if necessary
XU / E Coolant Hoses Inspect
D Crankcase Vent Inspect
D Drive Belt Inspect
D Driveshaft Yoke Inspect
XU / E Engine Oil & Filter Change Change oil and filter, inspect used oil for contaminants
D / E Evaporative Emission Control System Inspect
E Exhaust System Inspect; tighten, adjust
D Fasteners Inspect; tighten if necessary
D Fuel System Inspect; clean
D Headlamps Inspect; adjust if necessary
D Radio / Radio Software Update annually. Please see your dealer.
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
D Steering Inspect
D Swingarm Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

15,000 mi (24,000 km) Service

Code Item Action
D / XU Air Filter Replace
D ABS components Inspect
  Battery Check terminals; clean; test
D Brake Fluid Change every two years (DOT 4)
XU Brake Pads Inspect pad wear; replace if worn beyond service limit
D Brake Pedal Inspect; adjust if necessary
  Clutch Fluid Inspect; add fluid as required
D Clutch Pedal Inspect; adjust if necessary
XU / E Coolant Hoses Inspect
D Crankcase Vent Inspect
D Drive Belt Inspect
D Driveshaft Yoke Inspect
XU / E Engine Oil & Filter Change Change oil and filter, inspect used oil for contaminants
D / E Evaporative Emission Control System Inspect
E Exhaust System Inspect; tighten, adjust
D Fasteners Inspect; tighten if necessary
D Fuel System Inspect; clean
D Radio / Radio Software Update annually. Please see your dealer.
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
D Steering Inspect
D Swingarm Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

20,000 mi (32,000 km) Service

Code Item Action
D / XU Air Filter Inspect; replace as necessary
D ABS components Inspect
  Battery Check terminals; clean; test
D Brake Fluid Change every two years (DOT 4)
XU Brake Pads Inspect pad wear; replace if worn beyond service limit
D Brake Pedal Inspect; adjust if necessary
  Clutch Fluid Inspect; add fluid as required
D Clutch Pedal Inspect; adjust if necessary
XU / E Coolant Hoses Inspect
D Crankcase Vent Inspect
D Drive Belt Inspect
D Driveshaft Yoke Inspect
XU / E Engine Oil & Filter Change Change oil and filter, inspect used oil for contaminants
D / E Evaporative Emission Control System Inspect
E Exhaust System Inspect; tighten, adjust
D Fasteners Inspect; tighten if necessary
D Fuel System Inspect; clean
D Headlamps Inspect; adjust if necessary
D Radio / Radio Software Update annually. Please see your dealer.
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
D Steering Inspect
D Swingarm Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

25,000 mi (40,000 km) Service

Code Item Action
D / XU Air Filter Inspect; replace as necessary
D ABS components Inspect
  Battery Check terminals; clean; test
D Brake Fluid Change every two years (DOT 4)
XU Brake Pads Inspect pad wear; replace if worn beyond service limit
D Brake Pedal Inspect; adjust if necessary
  Clutch Fluid Inspect; add fluid as required
D Clutch Pedal Inspect; adjust if necessary
XU / E Coolant Hoses Inspect
D Crankcase Vent Inspect
D Drive Belt Inspect
D Driveshaft Yoke Inspect
XU / E Engine Oil & Filter Change Change oil and filter, inspect used oil for contaminants
D / E Evaporative Emission Control System Inspect
E Exhaust System Inspect; tighten, adjust
D Fasteners Inspect; tighten if necessary
D Fuel System Inspect; clean
D Fuel Filter Replace
D Radio / Radio Software Update annually. Please see your dealer.
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
D / E Spark Plugs Inspect
D Steering Inspect
D Swingarm Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

30,000 mi (48,000 km) Service

Code Item Action
D / XU Air Filter Replace
D ABS components Inspect
  Battery Check terminals; clean; test
D Brake Fluid Change every two years (DOT 4)
XU Brake Pads Inspect pad wear; replace if worn beyond service limit
D Brake Pedal Inspect; adjust if necessary
  Clutch Fluid Replace fluid
D Clutch Pedal Inspect; adjust if necessary
D / XU Coolant Drain / Refill cooling system
XU / E Coolant Hoses Inspect
D Crankcase Vent Inspect
D Drive Belt Inspect
D Driveshaft Yoke Inspect
XU / E Engine Oil & Filter Change Change oil and filter, inspect used oil for contaminants
D / E Evaporative Emission Control System Inspect
E Exhaust System Inspect; tighten, adjust
D Fasteners Inspect; tighten if necessary
D Fuel System Inspect; clean
D Headlamps Inspect; adjust if necessary
D Radio / Radio Software Update annually. Please see your dealer.
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
D Steering Inspect
D Spark Plugs Replace
D Swingarm Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns
D Valve Lash Inspect

35,000 mi (56,000 km) Service

Code Item Action
D / XU Air Filter Inspect; replace as necessary
D ABS components Inspect
  Battery Check terminals; clean; test
D Brake Fluid Change every two years (DOT 4)
XU Brake Pads Inspect pad wear; replace if worn beyond service limit
D Brake Pedal Inspect; adjust if necessary
  Clutch Fluid Inspect; add fluid as required
D Clutch Pedal Inspect; adjust if necessary
XU / E Coolant Hoses Inspect
D Crankcase Vent Inspect
D Drive Belt Inspect
D Driveshaft Yoke Inspect
XU / E Engine Oil & Filter Change Change oil and filter, inspect used oil for contaminants
D / E Evaporative Emission Control System Inspect
E Exhaust System Inspect; tighten, adjust
D Fasteners Inspect; tighten if necessary
D Fuel System Inspect; clean
D Radio / Radio Software Update annually. Please see your dealer.
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
D Steering Inspect
D Swingarm Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

40,000 mi (64,000 km) Service

Code Item Action
D / XU Air Filter Inspect; replace as necessary
D ABS components Inspect
  Battery Check terminals; clean; test
D Brake Fluid Change every two years (DOT 4)
XU Brake Pads Inspect pad wear; replace if worn beyond service limit
D Brake Pedal Inspect; adjust if necessary
  Clutch Fluid Inspect; add fluid as required
D Clutch Pedal Inspect; adjust if necessary
XU / E Coolant Hoses Inspect
D Crankcase Vent Inspect
D Drive Belt Inspect
D Driveshaft Yoke Inspect
XU / E Engine Oil & Filter Change Change oil and filter, inspect used oil for contaminants
D / E Evaporative Emission Control System Inspect
E Exhaust System Inspect; tighten, adjust
D Fasteners Inspect; tighten if necessary
D Fuel System Inspect; clean
D Headlamps Inspect; adjust if necessary
D Radio / Radio Software Update annually. Please see your dealer.
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
D Steering Inspect
D Swingarm Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

45,000 mi (72,000 km) Service

Code Item Action
D / XU Air Filter Replace
D ABS components Inspect
  Battery Check terminals; clean; test
D Brake Fluid Change every two years (DOT 4)
XU Brake Pads Inspect pad wear; replace if worn beyond service limit
D Brake Pedal Inspect; adjust if necessary
  Clutch Fluid Inspect; add fluid as required
D Clutch Pedal Inspect; adjust if necessary
XU / E Coolant Hoses Inspect
D Crankcase Vent Inspect
D Drive Belt Inspect
D Driveshaft Yoke Inspect
XU / E Engine Oil & Filter Change Change oil and filter, inspect used oil for contaminants
D / E Evaporative Emission Control System Inspect
E Exhaust System Inspect; tighten, adjust
D Fasteners Inspect; tighten if necessary
D Fuel System Inspect; clean
D Radio / Radio Software Update annually. Please see your dealer.
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
D Steering Inspect
D Swingarm Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns

50,000 mi (80,000 km) Service

Code Item Action
D / XU Air Filter Inspect; replace as necessary
D / XU Angle Drive Fluid Replace fluid
D ABS components Inspect
  Battery Check terminals; clean; test
D Brake Fluid Change every two years (DOT 4)
XU Brake Pads Inspect pad wear; replace if worn beyond service limit
D Brake Pedal Inspect; adjust if necessary
  Clutch Fluid Inspect; add fluid as required
D Clutch Pedal Inspect; adjust if necessary
XU / E Coolant Hoses Inspect
D Crankcase Vent Inspect
D Drive Belt Inspect
D Driveshaft Yoke Inspect
XU / E Engine Oil & Filter Change Change oil and filter, inspect used oil for contaminants
D / E Evaporative Emission Control System Inspect
E Exhaust System Inspect; tighten, adjust
D Fasteners Inspect; tighten if necessary
D Fuel System Inspect; clean
D Fuel Filter Replace
D Headlamps Inspect; adjust if necessary
D Radio / Radio Software Update annually. Please see your dealer.
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
D / E Spark Plugs Inspect
D Steering Inspect
D Swingarm Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns
D / XU Transmission Fluid Replace fluid

100,000 mi (160,000 km) Service

Code Item Action
D / XU Air Filter Inspect; replace as necessary
D / XU Angle Drive Fluid Replace fluid
D ABS components Inspect
  Battery Check terminals; clean; test
D Brake Fluid Change every two years (DOT 4)
XU Brake Pads Inspect pad wear; replace if worn beyond service limit
D Brake Pedal Inspect; adjust if necessary
  Clutch Fluid Replace
D Clutch Pedal Inspect; adjust if necessary
D / XU Coolant Drain / Refill cooling system
XU / E Coolant Hoses Inspect
D Crankcase Vent Inspect
D Drive Belt Inspect
D Driveshaft Yoke Inspect
XU / E Engine Oil & Filter Change Change oil and filter, inspect used oil for contaminants
D / E Evaporative Emission Control System Inspect
E Exhaust System Inspect; tighten, adjust
D Fasteners Inspect; tighten if necessary
D Fuel System Inspect; clean
D Fuel Filter Replace
D Headlamps Inspect; adjust if necessary
XU Radiator Inspect
D Radio / Radio Software Update annually. Please see your dealer.
D Rear Shock Absorber Replace
D Rear Wheel Alignment Inspect; adjust if necessary
D / E Spark Plugs Replace
D Steering Inspect
D Swingarm Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns
D / XU Transmission Fluid Replace fluid
D Valve Lash Inspect

150,000 mi (240,000 km) Service

Code Item Action
D / XU Air Filter Inspect; replace as necessary
D / XU Angle Drive Fluid Replace fluid
D ABS components Inspect
  Battery Check terminals; clean; test
XU / E Belt, Accessory Inspect
D Brake Fluid Change every two years (DOT 4)
XU Brake Pads Inspect pad wear; replace if worn beyond service limit
D Brake Pedal Inspect; adjust if necessary
  Clutch Fluid Replace
D Clutch Pedal Inspect; adjust if necessary
D / XU Coolant Drain / Refill cooling system
XU / E Coolant Hoses Inspect
D Crankcase Vent Inspect
D Drive Belt Inspect
D Driveshaft Yoke Inspect
XU / E Engine Oil & Filter Change Change oil and filter, inspect used oil for contaminants
D / E Evaporative Emission Control System Inspect
E Exhaust System Inspect; tighten, adjust
D Fasteners Inspect; tighten if necessary
D Fuel System Inspect; clean
D Fuel Filter Replace
D Headlamps Inspect; adjust if necessary
XU Radiator Inspect
D Radio / Radio Software Update annually. Please see your dealer.
D Rear Shock Absorber Inspect; adjust if necessary
D Rear Wheel Alignment Inspect; adjust if necessary
D / E Spark Plugs Inspect
D Steering Inspect
D Swingarm Inspect
D Tires / Wheels Inspect tread depth, sidewall cracking, wear patterns
D / XU Transmission Fluid Replace fluid
D Valve Lash Inspect
Parent topic: Periodic Maintenance